meta data for this page
This is an old revision of the document!
1.B.2.b - Natural Gas
Category Code | Method | AD | EF | ||||||||||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
1.B.2.b | T2, T3, M | AS | CS |
Key Category | NOx | NMVOC | SO2 | NH3 | PM2_5 | PM10 | TSP | BC | CO | PB | Cd | Hg | Diox | PAH | HCB |
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
1.B.2.b | -/- | -/- | -/- | - | - | - | - | - | -/- | - | - | - | - | - | - |
.
1.B.2.b.i - Exploration
Source category 1.B.2.b.i is considered together with source category 1.B.2.a.i (Oil, exploration). Consequently, the aggregated, non-subdivided data of 1.B.2.b.i are included in source category 1.B.2.a.i.
1.B.2.b.ii - Production
The emissions of source category 1.B.2.b.ii consist of emissions related to production. Since 1998, the Federal Association of the Natural gas, Oil and Geothermal Energy Industries (BVEG) has determined the emissions from production and published the relevant data in its statistical report.
activity data | Unit | 1990 | 1995 | 2000 | 2005 | 2010 | 2015 | 2020 | 2021 |
---|---|---|---|---|---|---|---|---|---|
produced quantities of natural gas | Billion m³ | 15.3 | 19.1 | 20.1 | 18.8 | 12.7 | 8.6 | 5.2 | 5.2 |
Source of emission factor | Substance | Unit | Value |
---|---|---|---|
Natural gas production | NMVOC | kg/ 1000 m³ | 0.002 |
1.B.2.b.iii - Processing
The emissions of this category consist of emissions from the activities of pretreatment and processing. After being brought up from underground reserves, natural gas is first treated in drying and processing plants. As a rule, such pretreatment of the natural gas takes place in facilities located directly at the pumping stations. Such processes separate out associated water from reserves, along with liquid hydrocarbons and various solids. Glycol is then used to remove the water vapour remaining in the gas (p. 25)1). Natural gas dehydration systems are closed systems. For safety reasons, all of such a system's overpressure protection devices are integrated within a flare system. When such protection devices are triggered, the surplus gas is guided to a flarehead, where it can be safely burned. After drying, the natural gas is ready for sale and can be delivered to customers directly, via pipelines 2). The relevant quantities of flared gas are reported under 1.B.2.c. The natural gas drawn from Germany's Zechstein geological formation contains hydrogen sulphide. In this original state, the gas – known as “sour gas” – has to be subjected to special treatment. Due to the hazardousness of hydrogen sulphide, this gas is transported via separate, specially protected pipelines to German processing plants that wash out its hydrogen sulphide via chemical and physical processes. About 40 % of the natural gas extracted in Germany is sour gas 3). The natural gas that leaves processing plants is ready for use. The hydrogen sulphide is converted into elementary sulphur and is used primarily by the chemical industry, as a basic raw material.
Unit | 1990 | 1995 | 2000 | 2005 | 2010 | 2015 | 2020 | 2021 | |
---|---|---|---|---|---|---|---|---|---|
Sulphur production from natural gas production | kt | 915 | 1,053 | 1,100 | 1,050 | 832 | 628 | 353 | 382 |
For processing of sour gas, data of the BVEG (the former WEG) for the period since 2000 are used. This data is the result of the BVEG members' own measurements and calculations. For calculation of emissions from sour-gas processing, a split factor of 0.4 relative to the activity data is applied. That split factor is based on the WEG report [1] on sour-gas processing.
Source of emission factor | Substance | Unit | Value |
---|---|---|---|
Treatment of sour gas | NMVOC | kg/ 1000 m³ | 0.004 |
Treatment of sour gas | CO | kg/ 1000 m³ | 0.043 |
Treatment of sour gas | NOx | kg/ 1000 m³ | 0.011 |
Treatment of sour gas | SO2 | kg/ 1000 m³ | 0.140 |
1.B.2.b.iv - Transmission
This source category's emissions consist of emissions from activities of gas producers and suppliers. In Germany, natural gas is transported from production and processing companies/plants to gas suppliers and other processors. In addition, natural gas is imported and transmitted via long-distance pipelines. Almost all of the pipelines used to transmit natural gas are steel pipelines 4).
One important emissions pathway consists of the compressors that are used to maintain pressure in pipelines. They are spaced at intervals of about 100 km along lines 5). At present, the compressors involved have a total power output of about 2,585 MW 6). The pipelines are also fitted with shut-off devices (sliding sleeves), which are safety mechanisms located at intervals of about 30 km along high-pressure pipelines, and with systems for regulating and measuring gas pressure.
In pipeline inspection and cleaning, tools known as pipeline inspection gauges (“pigs”) are used. In a pipeline system, a pig moves, driven by the gas flow, from a launching station to a receiving station (pig trap). Systems for launching and catching pigs can be either fixed or portable. Small quantities of methane are emitted in both insertion and removal of pigs. In addition, pig traps can develop leaks. Normally, however, such traps are regularly monitored for leaks and repaired as necessary. Not all types of pipelines can be pigged; diameter reductions, isolation valves, bends, etc. in pipelines can block pigs. These emissions have been estimated in the framework of a study carried out by the firm of DBI Gas- und Umwelttechnik GmbH 7).
Unit | 1990 | 1995 | 2000 | 2005 | 2010 | 2015 | 2020 | 2021 | |
---|---|---|---|---|---|---|---|---|---|
Length of transmission pipelines | km | 22,696 | 28,671 | 32,214 | 34,086 | 35,503 | 34,270 | 33,809 | 34,035 |
Cavern reservoirs | Billion m³ | 2.8 | 4.8 | 6.1 | 6.8 | 9.2 | 14.3 | 15.1 | 14.8 |
Porous-rock reservoirs | Billion m³ | 5.2 | 8.5 | 12.5 | 12.4 | 12.1 | 9.8 | 8.6 | 8.5 |
Most of the gas extracted in Germany is moved via pipelines from gas fields and their pumping stations (either on land or off the coast). Imported gas is also transported mainly via pipelines.
The emission factor for underground natural gas storage was derived via surveys of operators and analysis of statistics on accidents / incidents 8), and it is valid for porous storage and cavern-storage facilities. It is seen as very conservative. All other emission factor have been obtained from the research project 9) with using the split factor described on chapter 6.
Source of emission factor | Substance | Unit | Value |
---|---|---|---|
Cavern reservoirs | NMVOC | kg/ 1000 m³ | 0,001 |
Porous-rock reservoirs | NMVOC | kg/ 1000 m³ | 0,001 |
1.B.2.b.v - Distribution
The emissions caused by gas distribution have decreased slightly, even though gas throughput has increased considerably and the distribution network has been enlarged considerably with respect to its size in 1990. One important reason for this improvement is that the gas-distribution network has been modernised, especially in eastern Germany. In particular, the share of grey cast-iron lines in the low-pressure network has been reduced, with such lines being supplanted by low-emissions plastic pipelines. Another reason for the reduction is that fugitive losses in distribution have been reduced through a range of technical improvements (tightly sealing fittings such as flanges, valves, pumps, compressors) undertaken in keeping with emissions-control provisions in relevant regulations (TA Luft (1986) and TA Luft (2002)).
Unit | 1990 | 1995 | 2000 | 2005 | 2010 | 2015 | 2019 | 2020 | |
---|---|---|---|---|---|---|---|---|---|
Distribution network of natural gas | km | 246,710 | 366,987 | 362,388 | 402,391 | 471,886 | 474,57 | 489,100 | 492,500 |
Number of natural-gas-powered vehicles | No | -.- | -.- | 7,500 | 28,500 | 90,000 | 97,804 | 98,460 | 100,807 |
Pipeline network
The calculation was carried out using the Tier 3 method, on the basis of the available network statistics of the German Association of Energy and Water Industries (BDEW) 10) and of own surveys. In the early 1990s, emissions from distribution of town gas were also taken into account in calculations. In 1990, the town gas distribution network accounted for a total of 16 % of the entire gas network. Of that share, 15 % consisted of grey cast-iron lines and 85 % consisted of steel and ductile cast-iron lines. The emission factors have been obtained from the research project 11) with using the split factor described on chapter 6..
Storage reservoirs
Man-made above-ground storage facilities, for storage of medium-sized quantities of natural gas, help meet and balance rapid fluctuations in demand. In Germany, spherical and pipe storage tanks, and other types of low-pressure containers, are used for this purpose. Results from a relevant research project 12) have made it possible to derive new country-specific emission factors for this area. The emissions have been calculated in accordance with the Tier 2 method.
Liquefied natural gas (LNG)
Natural gas can be liquefied, at a temperature of -161°C, for ease of transport. The liquefaction process is highly energy-intensive, however, and is normally used only in connection with long-distance transports. Germany did not have LNG terminals before 2022. Gas imports arrive mostly in gaseous form, via long-distance pipelines, and they are included in 1.B.2.b.iv. Germany now has one natural gas liquefaction facility and two satellite LNG storage facilities. Since the storage and transfer processes at those facilities are subject to the most stringent standards possible, emissions there can be ruled out. Gas can escape only in connection with maintenance work, and the gas quantities involved are extremely small. The quantities do not exceed more than a few hundred kilograms 13).
In the 1990s, town gas (=coal gas) was supplied to households via distribution systems in East Germany and West-Berlin. The composition of coal gas varied in the different regions, consisting of hydrogen, carbon monoxide, methane and nitrogene.
1.B.2.b.vi - Post-Meter Emissions
The category describes emissions from leakage in the industrial sector and in the residential and institutional/commercial sectors as well as from natural gas-powered vehicles.
Leakage in the industrial sector and in the residential and institutional/commercial sectors
The activity data is based on own surveys.
activity data | Unit | 1990 | 1995 | 2000 | 2005 | 2010 | 2015 | 2020 | 2021 |
---|---|---|---|---|---|---|---|---|---|
Gas meters in the residential and institutional / commercial sector | Million | 10.3 | 12.7 | 12.8 | 13.3 | 12.9 | 13.0 | 13.1 | 13.1 |
The emission factors are country-specific, and they were determined via the research project by DVGW and GWI 14). They include start-stopp loses at all enduser devices. The study covers methane only. The appropriate NMVOC factor was derived from the publication 15) (refer to chapter 6).
Natural-gas-powered vehicles, and CNG fuelling stations
Use of vehicles running on natural gas continues to increase in Germany. Such vehicles are refuelled at CNG fuelling stations connected to the public gas network. In such refuelling, compressors move gas from high-pressure on-site tanks. Some 900 CNG fuelling stations are now in operation nationwide. In keeping with the stringent safety standards applying to refuelling operations and to the tanks themselves, the pertinent emissions are very low. In the main, emissions result via tank pressure tests and emptying processes.
Unit | 1990 | 1995 | 2000 | 2005 | 2010 | 2015 | 2020 | 2021 | |
---|---|---|---|---|---|---|---|---|---|
Number of natural-gas-powered vehicles | No | -.- | -.- | 7,500 | 28,500 | 90,000 | 97,804 | 100,807 | 101,688 |
Recalculations
Please refer to overarching chapter 1.B - Fugitive Emissions from fossil fuels
Planned improvements
No further improvements are planned.